Sunroof - Saturn Outlook Online Community
Reply
 
LinkBack Thread Tools
post #1 of 46 (permalink) Old 03-17-2008, 02:02 PM Thread Starter
Junior Member
 
Join Date: Mar 2008
Posts: 8
Sunroof



Has anyone had any problems with the sunroof leaking? I have 2007 Outlook which I purchased back in Jan 07. I have had to take it back to the dealers 4 times now for the same problem.
klhm60 is offline  
Sponsored Links
Advertisement
 
post #2 of 46 (permalink) Old 03-17-2008, 03:43 PM
Super Moderator
 
Join Date: Jan 2008
Posts: 297
Re: Sunroof

Below are comments about the problem I have made as well as links to 3 other threads from other sites that deal with the issue.

Good Luck.


Below are several posts I had with my experience on my Outlook (from an Outlook site). My understanding is that the 08's are corrected. Look not only at the sunroof drain but also the luggage racks. If you have an 07 and have not had any problems, make the dealer check and fix it before you do.


December 17th - We had not had any significant rain in Amarillo since I got my 07 back in June, and I had not had a problem while washing mine. Last week we had rain and mine started leaking down the drivers side seat belt, headliner and down into the emergency brake housing (flooding the floor board).

Dealer told me they were aware of the problem but that GM did not want to issue a recall since it may not effect everyone. Problem was that the drain tube on the moonroof was not connected, infact it was two inches short (they new this in production?). Dealer got in the fix kit, and did the work in one day. To dry out my truck the ran the engine (how long I don't know but it changed the MPG avg reading by 2) and ran the heat in the truck at 90 degrees.

I went to wash mine yesterday, and foud that it was leaking again over the drivers side. I be taking it in again.

January 3rd - I had the dealership fix the sunroof leak (tube not connected at factory, they had a repair kit for this, GM new about the problem [according to the dealership] but choose not to say anything and handle them on a problem by problem situation]. Since that was fixed I still had problems, and we think it was the luggage rack connections (mentioned by others previously). They went through and sealed anything that could be sealed, got all the stains out of the headliner and floor, time will tell but I feel confident that it has been corrected. The dealership was very accommodating and have taken care of the problems without hassle.

January 9th - Update: 1 rainstorm & 1 carwash = no leak!! Looks like it was the roof rack the second time around and the dealer got it fixed. They are also going to do a leather treatment on my seats as a courtesy for my troubles. They have bent over backwards for me. The service department manager has called me a couple of times to make sure everything is okay - what service!

January 15th - It wasn't that the hoses were shrinking up, they were never contected to begin with - to short. Glad your's is fixed.



January 5th - I had mine in again last week because of a leak again. It was the luggage rails. The way the sit, the rubber gaskit does not sit flush with the roof (it hangs over a narrow valley (for lack of a better word) and allows water to get up inside the bracket and run down the screw holes. They went through and sealed all of the screw holes with silicone, which should do the trick. From what I understand they have corrected the problem with the sunroofs in the 08's with a correct size drain tube. I would go for it.

January 7th - The dealership was wonderful and has fixed any of the problems. My beef is with GM and plant managers not fixing the problem when the found it at the factory. Seems to me a one day shut down and fix the tubes would have saved them money in the long run although it would have cost more for that one day. If these guys are fighting for our money you would think they would want to give us an error free car/truck (of course there would be exceptions for the un-forseen) to begin with.



http://www.acadiaforum.net/forum/index.php?topic=2910.0
http://www.enclaveforum.net/index.ph...30908#msg30908
http://www.saturnfans.com/forums/sho...d.php?t=109212

Signature: <br /><br />Proud Former Owner of a 2007 Outlook and 2009 Acadia
khansen30 is offline  
post #3 of 46 (permalink) Old 03-18-2008, 01:44 PM Thread Starter
Junior Member
 
Join Date: Mar 2008
Posts: 8
Re: Sunroof

khansen30 thanks for the feedback. I wish I would have known about this site before. The dealership I took mine too never heard of any problems thru GM. 1st they adjusted the sunroof's screws, the 2nd time around they replaced the windshield, the 3rd time around they replaced the sunroof's glass and the 4th time they realized that is was coming from the back moon roof and also something to do with these holes not being connected and forgot to plug them. Unfortunately after 4 visits and 41 days without my vehicle I still have this leak. The only good news is that they are goping to replace my vehicle with a new 2008.
klhm60 is offline  
post #4 of 46 (permalink) Old 03-21-2008, 10:11 PM
Member
 
Join Date: Nov 2007
Posts: 44
Re: Sunroof

Yesterday we had water leak out of the dome light in between the sunroofs. I hope they can fix this using the info here. When I called in they said they have never seen a problem like this before.
Kevin 07 XR is offline  
post #5 of 46 (permalink) Old 04-20-2008, 10:58 PM
Junior Member
 
Join Date: Apr 2008
Posts: 13
Re: Sunroof

Had my Outlook since Aug 07 and travelled about 17000km (10625mi) with it. After reading this thread I decided to check out the floor boards. Bad news, I noticed rust marks running around the metal linked to the emergency brake. I realized then that there has been a leak in the vehicle for a while. I wasn't imagining it after all. It happens after a car wash or heavy rain. The common signs are the resting foot pedal getting wet. Having it checked this week...let's see what's the excuse this time

2007 Saturn Outlook<br />78000km and barely going<br />Silver
SaturnNorth is offline  
post #6 of 46 (permalink) Old 04-21-2008, 11:05 AM
Super Moderator
 
Join Date: Jan 2008
Posts: 297
Re: Sunroof

At some point GM is going to have to do a recall on this. Water getting into the electrical is not good and they are only ticking off there customers by ignoring the problem.

Signature: <br /><br />Proud Former Owner of a 2007 Outlook and 2009 Acadia
khansen30 is offline  
post #7 of 46 (permalink) Old 04-21-2008, 10:36 PM
 
Join Date: May 2007
Posts: 59
Re: Sunroof

I believe the issue is with drain lines, either being too short or not connecting properly, which then allows water to spill out in unwanted ways...to the interior.

Has been a common Acadia/Outlook/Enclave thing, most of which dealers should actually be able to fix...but I've seen at least 2 Enclaves be repurchased after the leaks resulted in 3+ unsuccessful dealer repair trips. GM acknowledged the issue, and didn't put up much of a fight for the buybacks in those cases.

Here, the dealers need to get schooled quickly from GM by looking into their service bulletins for descriptions and fix details, and/or get in touch with their GM help and try to get the leaks fixed. If not, and it's tried multiple times, may be time for a buyback.
caddycruiser is offline  
post #8 of 46 (permalink) Old 04-22-2008, 10:13 AM
Super Moderator
 
Join Date: Jan 2008
Posts: 297
Re: Sunroof

I agree. The drain lines were too short and did not and never were connected. The service guy at my Saturn told me that, and they (factory) were aware of it at the time but did not want to correct and were going to let the dealers fix on whenever somebody had a leak, hoping that those in areas were it does not rain that much would not notice/have a problem thus saving money on the fix. It took 2 visits to get mine fixed, but, my dealer got my Outlook fixed and cleaned and put back together correctly so that it looks new. I couldn't be happier!

Now if all the other dealers would be as attentive, these problems could be fixed quickly and with out hassle. Sometimes the dealer plays dumb, but when they have people like those of us on these forums talking and figuring out their mistakes they start to sit up and take notice. I think at some of my urging my dealer now looks at these forums too to see the problems going on and I don't get those lame exuses as to the problems. The next generation of the Lambdas will be better thanks to the first two years of the new owners. I must say though that I hear of alot more problems with the Acadia's and Enclave engines and transmissions than the Outlooks. I don't know if it is because they are more picky or if the differences in the vehicles is that great. But some of the problems they are having I have never had.

Signature: <br /><br />Proud Former Owner of a 2007 Outlook and 2009 Acadia
khansen30 is offline  
post #9 of 46 (permalink) Old 04-23-2008, 06:11 PM
Junior Member
 
Join Date: Nov 2007
Posts: 16
Re: Sunroof

I bought a 2007 in February 2007. Now have 20,000 miles with the dual skyscape sunroofs. Most of the time my Outlook is outdoors being rained and snowed on. I run it through a car wash frequently. No leaks. Nothing. Sealed tight. It's perfect.
The Plainsman is offline  
post #10 of 46 (permalink) Old 04-29-2008, 09:44 AM
Junior Member
 
Join Date: Apr 2008
Posts: 13
Re: Sunroof

I made an appointment with my Saturn dealer and gave him heads up on my problem. He sounded very surprise and told me he never heard of a leaking problem. My appointment is set for next week. Well, it rained the last couple of days in Montreal. My floor boards were soaked! While driving, I could see the streams of water running along the plastic side on the passenger side. I can't believe what I saw. I also suspect this is happening since day one when my vehicle was manufactured and exposed to the outdoors. There are rust marks in the inside cabin on exposed metal. I highly recommend all those who purchased one during the first few days to take it to the carwash or leave it out it the rain. If you see a problem, you can return the vehicle for a new one in the first 30 days (I don't know about the US but it applies to Canada). TBC.

2007 Saturn Outlook<br />78000km and barely going<br />Silver
SaturnNorth is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Saturn Outlook Online Community forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page



Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome